My Build: The Good, The Bad & The Progress
:fingersx :
09-17-2009, 06:32 PM
#2105
could you imagine the dabaucle if the motor went for a 4th time. I bet this one was put together more meticulously than those guys have ever done in their lives.
wait, is that oil pooling under the car in that pic?
i keed! shouldnt be long til you get to enjoy your car! finally!
wait, is that oil pooling under the car in that pic?
i keed! shouldnt be long til you get to enjoy your car! finally!
09-17-2009, 06:40 PM
#2106
could you imagine the dabaucle if the motor went for a 4th time. I bet this one was put together more meticulously than those guys have ever done in their lives.
wait, is that oil pooling under the car in that pic?
i keed! shouldnt be long til you get to enjoy your car! finally!
wait, is that oil pooling under the car in that pic?
i keed! shouldnt be long til you get to enjoy your car! finally!
lets keep positive. 
09-17-2009, 10:04 PM
#2109
Registered User
iTrader: (2)
Join Date: Apr 2007
Location: Washington D.C.
Posts: 898
Likes: 0
Received 0 Likes
on
0 Posts
Is frank and justice being there while it's being tuned, I vaguely recall that earlier in the thread that they were going to be there. For the sake of everyone involved they should be there since the tear down showed no mechanical failure nor machining error(or tuning error besides slght det). Not saying it's Dave fault but for his sake he should have them there so they all over see the progress and there's no doubt in anyone mind and no chance of finger pointing. Good luck I think everyone hoping for success
Last edited by terps; 09-17-2009 at 10:06 PM.
09-18-2009, 03:52 AM
#2110
Everything went smoothly yesterday, Frank and Franz were not able to attend because of the schedule delays that had been realized earlier in the build process.
The car laid down nice power, but ran out of fuel sooner than the previous setup. This was explained to me as more than likely being caused by both turbos operating at full efficientcy and pushing more air
, perhaps Dave can chime in with a more technical explanation and a TQ #. The car pulls super clean with zero smoke out the pipes either on or off throttle.Anyway, the car put down a max of 615whp @ 20lbs in shootout mode
. I'm having the fuel setup installed now so we can make a bit more power and run another 5lbs of boost or so. Thanks to Dave, Mike, Robbie, Kevin and Tuna for hanging out while I was there. I will have the car back in a weekLots of vids coming later after I have time to sort through some of the footage. Mike has an *** whoopin camera that obviously takes great pics.
09-18-2009, 04:02 AM
#2111
Oh, I almost forgot, my car was evaluted for and article in Import Tuner Magazine and was "found to be lacking a bit in the aesthetics" department. I guess this means that because I don't have graphics on my car it's not mag material 
.
It would be nice to be in a writeup as some sort of validation for all the effort put into this car, but the stealth look is just more my style on the exterior
.
.It would be nice to be in a writeup as some sort of validation for all the effort put into this car, but the stealth look is just more my style on the exterior
.
09-18-2009, 05:31 AM
#2116
Car looks great Chris. Congrats. What psi do you plan to run on W/M vs running race gas? That's a lot of power - you may want to just leave it there for awhile before turning up the boost. Honestly I think you'll enjoy a power level lower than that for the street where you find a nice balance of worry free traction and solid acceleration. Modulating boost with your right foot to avoid spinning the tires in all the lower gears is no fun (imo for a dd) but if you can get a Vipec tune that can gradually increase the boost through the gears, that might be the best of both worlds.
09-18-2009, 06:54 AM
#2118
Banned
iTrader: (8)
Join Date: Oct 2006
Location: Sterling, VA
Posts: 650
Likes: 0
Received 0 Likes
on
0 Posts
Oil pressure has been holding very well. 30PSI+ (partially due to the high idle). At about 85% duty cycle I could not get any more fuel into the motor even after a bump in fuel pressure. This indicates that we're out of pump. I have to assume that this is due to the fact that we've got more airflow since one of the turbos isn't blocked partially with a rag. I feel like there's more in the setup but it was leaning out to mid 12's up top.
09-18-2009, 07:03 AM
#2119
Registered User
SWEEEEEEEET
Power sounds about right for a DD and you ran out of fuel at about the right point too for one pump.
Can't wait to see some vids with you behind the wheel!!!!
tom
Power sounds about right for a DD and you ran out of fuel at about the right point too for one pump.
Can't wait to see some vids with you behind the wheel!!!!
tom
09-18-2009, 07:08 AM
#2120
Registered User
iTrader: (18)
Join Date: Apr 2006
Location: Piscataway, NJ
Posts: 2,148
Likes: 0
Received 0 Likes
on
0 Posts
Attachment 259085Attachment 259086Attachment 259087Attachment 259088
Everything went smoothly yesterday, Frank and Franz were not able to attend because of the schedule delays that had been realized earlier in the build process.
The car laid down nice power, but ran out of fuel sooner than the previous setup. This was explained to me as more than likely being caused by both turbos operating at full efficientcy and pushing more air, perhaps Dave can chime in with a more technical explanation and a TQ #. The car pulls super clean with zero smoke out the pipes either on or off throttle.
Anyway, the car put down a max of 615whp @ 20lbs in shootout mode. I'm having the fuel setup installed now so we can make a bit more power and run another 5lbs of boost or so. Thanks to Dave, Mike, Robbie, Kevin and Tuna for hanging out while I was there. I will have the car back in a week
Lots of vids coming later after I have time to sort through some of the footage. Mike has an *** whoopin camera that obviously takes great pics.
Everything went smoothly yesterday, Frank and Franz were not able to attend because of the schedule delays that had been realized earlier in the build process.
The car laid down nice power, but ran out of fuel sooner than the previous setup. This was explained to me as more than likely being caused by both turbos operating at full efficientcy and pushing more air
, perhaps Dave can chime in with a more technical explanation and a TQ #. The car pulls super clean with zero smoke out the pipes either on or off throttle.Anyway, the car put down a max of 615whp @ 20lbs in shootout mode
. I'm having the fuel setup installed now so we can make a bit more power and run another 5lbs of boost or so. Thanks to Dave, Mike, Robbie, Kevin and Tuna for hanging out while I was there. I will have the car back in a weekLots of vids coming later after I have time to sort through some of the footage. Mike has an *** whoopin camera that obviously takes great pics.